新闻中心

联系我们

联系电话:

0311-89873058

 

联系手机:

13932157135

 

公司邮箱:

sjzgxbkj@163.com








川菲特三相智能伺服电子变压器简介

川菲特伺服电子变压器产品特点:

1.外形精巧、安装灵活

——模块式结构,能量密度高,重量轻(同功率仅传统三相变压器的约1/5);

——体积小,节省设备空间(仅传统三相变压器的约1/6)

——正面接线;

——壁挂式安装。

2.智能型输出

——瞬间过载能力可达5倍以上,输出电压稳定,能自动调节伺服系统所需电流,输出电流不受电网电压波动的影响、电流响应速率达到μS级,能够很好的保证伺服系统瞬间启动和突然加速时的运行需要。

3.电网干扰屏蔽

——输入端带浪涌抑制和宽频杂波吸收电路,能过滤电网干扰以保证伺服系统安全使用;

——输出端带杂波吸收电路,避免负载对电网的反向杂波污染。

4.电磁兼容性能

——本产品工作噪声已作清除处理,无电磁辐射,为无噪声输出,变压器可置于电控柜内,对周边设备无任

何干扰。

5.安全和保护性能

——本产品具有双重保护结构,保证能在较恶劣情况下正常输出。

——输入线连接错误时自动闭锁输出,恢复正确接线后即可正常工作。

6.输入输出

    标准输入:额定三相380V(允许输入范围三相340V~440V,对应输出低于220V)

    瞬间输入:瞬间耐压不高于三相1600V,对应输出低于240V;

    损坏电压:长时间电压高于三相517V或瞬间电压高于1600V,变压器保护损坏,截止输出。

7.能量传输性能

——能量传输效率达97%以上,发热量极小(传统变压器的十分之一)且散热良好,输出能量稳定,绿色环保。

8.贴合中国使用环境

——50%的短时间过载能力,可长时间不间断连续工作;

——全灌封式结构,能在极苛刻环境中正常运行,适用环境温度-30℃至+65℃,适应较高的空气湿度,安装海拔可达3000M

——终身免维护。

9.高性价比

——较传统工频变压器便宜,性价比高。

10.寿命

——性能稳定可靠,返修率≤0.05‰,寿命长达十年以上。

变压器的工作原理

伺服变压器

一、Features of TRANFILTE Servo Transformer

1.Unique Appearance and Flexible Installation

——Modular Structure:high energy density,light weight (only traditional three-phase transformer 1/5 or so);

——Small size:  Save equipment space(only traditional three-phase transformer 1/6 or so);

——Front Wiring;

——Wall hanging type installation.

2.Intelligent output

——Instantaneous overload capacity can reach more than 5 times, the output voltage stability, and can automatically adjust the current according to the need of servo system. The output current is not affected by the fluctuation of the power system voltage, the current response rate to reach μS level, can be very good guarantee instantaneous startup and acceleration of the servo system to run.

3. Grid Interference Shielding

——The input with surge suppression and broadband noise absorbing circuit, can filter the grid interference to ensure the safety in servo system using;

——Output with noise absorbing circuit and avoid reverse noise pollution of load.

4. EMC Performance

——This product work noise has made clear, no electromagnetic radiation,noiseless output, the transformer can be placed in electric control cabinet, without any interference to the surrounding equipment

5. Safety and Protection performance

——This product has a dual protection structure, which can guarantee the normal output in a bad situation.

——Output locked when input line connection error, recovery after the connection can work normally.

6. Input and Output

——Standard input: 

Rated input: three-phase 380 v(allowed range:three-phase 340-440V,corresponding output: <220V)

——Instantaneous input: 

Instant voltage is not higher than 1600V, the corresponding output is lower than 240 v;

——Damage voltage: 

long time higher than that of three-phase voltage 517V or instantaneous voltage is higher than 1600 v, transformer protection will be damaged, as output.

7. Energy Transmission Performance

——Energy transfer efficiency of more than 97%, minimum of calorific value (ten percent of the traditional transformer) and good heat dissipation, the output energy stability, green environmental protection.

8. Joint China's Use Of The Environment

——50% of the overload capacity in short time,long time uninterrupted work continuously;

——All potting type structure, can run normally in a very harsh environment for temperature -30℃~+ 65℃, adapt to the high air humidity, installation of up to 3000m above sea level

——Free maintenance for life.

9. High Cost Performance

——cheaper than traditional power frequency transformer, high cost performance.

10.Life

——Performance is stable and reliable, repair rate 0.05 ‰, or more life than ten years.

 版权所有 石家庄光祥本科技有限公司   备案号:冀ICP备11004944号-3

地址:石家庄桥西区振二街南苑4号楼2单元903室

在线客服
联系方式
热线电话
0311-89873058
上班时间
周一到周五
二维码
二维码
在线客服